my-cart-icon svg-arrow-next svg-arrow-prev

Waterous Slide in CAFS System, 70-35-GP-FT

No reviews yet Write a Review
$35,995.95
SKU:
WATEROUS-70-35-GP-FT
Shipping:
$850.00 (Fixed Shipping Cost)
Waterous Slide in CAFS System, 70-35-GP-FT
Slide Into Enhanced Portable Power

The Waterous Slide in CAFS System is a slide-in, modular, portable compressed air foam unit designed and constructed to discharge water, foam solution or compressed air foam.

The system develops a minimum of 35 GPM of water at 100 PSIG (132 L/min @ 6.9 bar) and 35 CFM of air at 100 PSIG (0.9 m3/min @ 6.9 bar) simultaneously and compressed air foam discharge pressures up to 130 PSIG (9 bar).

Water Flow:
GPM:
70
l/min:

265
l/sec:
4.4
SCFM:
35
M3/min:
0.9

Air Flow:
CFM:
35
M3/Min
0.9

Pressure:
PSI:
100
Bar:
6.9
kPa:
690
MPa:
.69

Pump and Transmission:

  • Centrifugal water pump utilizing close-grained iron case, reinforced nylon impeller, stainless steel shaft and maintenance-free mechanical seal
  • 1-1/2 inch Intake
  • 1-1/2 inch Discharge
  • Pneumatic oil-free primer capable of priming the water pump through 20 feet (6 m) of 2-1/2 (63.5 mm) inch hard intake hose with a 10 foot (3 m) lift
  • Controls are mounted on the operator's panel.
  • "Poly Chain" drive transmission with an automatic tensioner and 8mm pitch sprockets

Engine
:
  • Briggs and Stratton engine, Vanguard model 380447, two-cylinder, air cooled, sintered iron cylinder liners delivering a maximum of 23 horsepower (17.2 kW), 627 cc displacement, four-cycle, gasoline fueled
  • Two (2) year manufacturer's warranty
  • The engine draws fuel from a fuel tank (not supplied) via a pulse fuel pump
  • Pressure lube system with spin-on oil filter
  • An extension hose is installed on the engine oil drain with a valve located at the oil pan and a plug installed in the end of the hose to facilitate oil changes
  • 12-volt electric with 20A alternator, electric ignition and start switch
  • Spark arrestor muffler

Dimensions and Weights
:
Length:
33" (84 cm)
Width:
40" (102 cm)
Height:
33" (84 cm)
Dry Weight:

450 lbs. (204 kg)

Frame
:
  • High-strength, welded tubular steel frame provided to support and contain the entire CAFS unit
  • Constructed of 1-1/4" tubing with radius corners and a durable corrosion-resistant powder coat finish

Pump Operator Panel
:
  • Engine Ignition/Start Switch
  • Engine Throttle Control
  • Engine Choke Control
  • 2-1/2" Oil-Free Master Water Pressure Gauge
  • 2-1/2" Oil-Free Master Air Pressure Gauge
  • Auto-Sync Compressor Pressure Controls
  • Foam Proportioner Control
  • Pneumatic Primer ControlWater/Solution Discharge Valve Control, 1/4-turn swing type
  • Air Discharge Valve Control, 1/4-turn
  • Two (2) Shielded Pump Panel Lights

Foam Proportioner
:
  • Fire Troll FT-150 System

Warranty
:
  • Waterous Five-Year Limited Warranty

Benefits of Compressed Air Foam:
  • 80% of water content in the foam is
  • effectively used for fire fighting
  • Improved firefighter safety
  • Faster knockdown time
  • Less property damage
  • Less water used

Air Compressor
:
  • 4-cylinder rotary screw that is rated at 35 scfm (.9 m3/min) equipped with a low oil pressure warning light.

Auto Sync Balancing System
:
Automatically maintains the air pressure within +/- 5% of the water pump pressure throughout the pressure range. The Auto Sync Balancing System is located on the operator's panel and allows for the following modes:
  • Automatic - Air pressure matched to water pressure
  • Fixed - Air pressure defaults to manual setting on compressor mounted control valve
  • Unload - Air pressure reduced to 40 psig (2.8 bar) for standby operations

Compressed Air Delivery
:
All air hoses, fittings and piping are rated to a minimum of 250 psi (17.5 bar). Locations where discharge air runs at high temperatures, stainless steel wire braid reinforced Teflon hoses are used. Brass or bronze air check valves are utilized at plumbing air injection points to prevent water or foam back flow into the air lines.

Inlet
:
Inlet piping is 1.5" brass pipe with a 2" 3-way tank to pump / overboard suction with a 1-1/2" NST female swivel hose connection.

Discharge:
Plumbing to one 1.5" discharge outlet is 1-1/2" brass pipe and 1-1/2" high-pressure hydraulic hose with brass or stainless steel fittings. Discharge valve is a full-flow, quarter-turn type constructed of bronze. Check valves of bronze or brass are installed in each discharge to prevent foam back flow into the water pump. A 1" tank fill valve for connection to a booster tank is also provided.

Drains:
Panel mounted drain valves are provided to drain water from the water pump, discharge manifold and compressor cooler.

Foam Proportioner:
Fire Troll FT-150 System: The fire troll meters the percentage of foam concentrate, based on current flow into the water stream. A check valve ahead of the foam injection point prevents back flow. The Fire Troll control valve is mounted on the pump panel and allows for foam percentages up to 1% mix ratio.

This product hasn't received any reviews yet. Be the first to review this product!
Write a Review
Returns Policy

You may return most new, unopened items within 30 days of delivery for a full refund. We'll also pay the return shipping costs if the return is a result of our error (you received an incorrect or defective item, etc.).

You should expect to receive your refund within four weeks of giving your package to the return shipper, however, in many cases you will receive a refund more quickly. This time period includes the transit time for us to receive your return from the shipper (5 to 10 business days), the time it takes us to process your return once we receive it (3 to 5 business days), and the time it takes your bank to process our refund request (5 to 10 business days).

If you need to return an item, simply login to your account, view the order using the "Complete Orders" link under the My Account menu and click the Return Item(s) button. We'll notify you via e-mail of your refund once we've received and processed the returned item.

Shipping

We can ship to virtually any address in the world. Note that there are restrictions on some products, and some products cannot be shipped to international destinations.

When you place an order, we will estimate shipping and delivery dates for you based on the availability of your items and the shipping options you choose. Depending on the shipping provider you choose, shipping date estimates may appear on the shipping quotes page.

Please also note that the shipping rates for many items we sell are weight-based. The weight of any such item can be found on its detail page. To reflect the policies of the shipping companies we use, all weights will be rounded up to the next full pound.

Related Products